||The neutrality of this article is disputed. (March 2014)|
Sludge refers to the residual, semi-solid material left from industrial wastewater, or sewage treatment processes. It can also refer to the settled suspension obtained from conventional drinking water treatment, and numerous other industrial processes. The term is also sometimes used as a generic term for solids separated from suspension in a liquid; this 'soupy' material usually contains significant quantities of 'interstitial' water (between the solid particles).
In the industrialized world, cities in particular have had a difficult time dealing with sewage waste. In 1992, a United States ban on ocean dumping of human sewage sludge went into effect, leaving cities the expensive option of having to dispose sewage waste in landfills.
Seeing as sewage contains not only heavy metals and disease pathogens such as Clostridium difficile but nutrients as well, companies such as Synagro embraced the nutrient idea and marketed sludge as "biosolids" to farmers as a free fertilizer.
When fresh sewage or wastewater is added to a settling tank, approximately 50% of the suspended solid matter will settle out in an hour and a half. This collection of solids is known as raw sludge or primary solids and is said to be "fresh" before anaerobic processes become active. The sludge will become putrescent in a short time once anaerobic bacteria take over, and must be removed from the sedimentation tank before this happens.
This is accomplished in one of two ways. In an Imhoff tank, fresh sludge is passed through a slot to the lower story or digestion chamber where it is decomposed by anaerobic bacteria, resulting in liquefaction and reduced volume of the sludge. After digesting for an extended period, the result is called "digested" sludge and may be disposed of by drying and then landfilling. More commonly with domestic sewage, the fresh sludge is continuously extracted from the tank mechanically and passed to separate sludge digestion tanks that operate at higher temperatures than the lower story of the Imhoff tank and, as a result, digest much more rapidly and efficiently.
Excess solids from biological processes such as activated sludge may still be referred to as "sludge", but "biosolids" or "compost" are public relations terms sometimes used to refer to treated human waste. Industrial wastewater solids are also referred to as sludge, whether generated from biological or physical-chemical processes. Surface water plants also generate sludge made up of solids removed from the raw water.
- 1 Pollutant
- 2 Dangers
- 3 Lawsuits and court cases
- 4 Local government ordinances and complaints
- 5 Background and history
- 6 Hazardous waste
- 7 Treatment process
- 8 Biosolids
- 9 Political issue
- 10 Alternative pathways for sludge reuse
- 11 See also
- 12 References
- 13 Further reading
The term "pollutant" is defined as part of the EPA 503 rule. The components of sludge have pollutant limits defined by the EPA. "A Pollutant is an organic substance, an inorganic substance, a combination of organic and inorganic substances, or a pathogenic organism that, after discharge and upon exposure, ingestion, inhalation, or assimilation into an organism either directly from the environment or indirectly by ingestion through the food chain, could, on the basis of information available to the Administrator of EPA, cause death, disease, behavioral abnormalities, cancer, genetic mutations, physiological malfunctions (including malfunction in reproduction), or physical deformations in either organisms or offspring of the organisms." The maximum component pollutant limits by the US EPA are:
|Pollutant||Ceiling concentration (milligrams per kilogram)|
There are thousands other components of sludge that remain untested/undetected disposed of from modern society that also end up in sludge (pharmaceuticals, nano particles, etc.) which has been proven to be hazardous to both human and ecological health.
In 2011, the EPA commissioned a study at the United States National Research Council (NRC) to determine the health risks of sludge. In this document the NRC pointed out that many of the dangers of sludge are simply unknown and unassessed. Additionally "Regulations that limit contact with biosolids do not prevent environmental processes in the conceptual model such as aerosolization or erosion and the death or multiplication of pathogens."
Recent STEC research has stated that "Fecal material may contaminate meat during slaughter, may be washed or blown into lakes or drinking water sources, or may be deposited on fruits and vegetables by use of manure for fertilization or sewage-contaminated water for irrigation. Some animals, such as insects, birds, and rodents, may transport these bacteria from feces to drinking water or foods"
"Addition of fresh biosolids to soil caused E. coli levels to rise to significantly greater values due to unknown mechanisms involving the existing microflora of natural soils. However, when sterile biosolids were added to soil there was also an increase in pathogen numbers indicating that the addition of organic nutrients alone may result in multiplication of pathogens (Unc et al. 2006). " 
"Following applications in different seasons, repeated assessments of bacterial concentrations in biosolid clumps, using most-probable-number (MPN) techniques, found sustained high levels of these bacteria. Bacterial concentrations were often well above soil background levels at 6 months, and in some cases 11-12 months, after land application. Survival in surface-applied biosolids was similar to that for biosolids incorporated into the soil, and between application rates of 10 or 30 dry t/ha" 
"Sudden and substantial increases in fecal coliform and E. coli have been measured by a number of researchers and utilities after dewatering of digested sludges. Research has seemed to indicate that the increase is not due to floc dispersion or due to centrifuge contamination, although the results are not definitive. The results appear to support the conclusion that bacteria are underestimated after digestion because they become non-culturable, and after dewatering the bacteria are reactivated, making them culturable again."
Clostridium difficile has been detected incoming to WWTP and detected in sludges spread on farm land. "Although there is a consensus among independent risk assessments on the probability of aerosol infection from enteroviruses, inclusion of adenovirus and especially norovirus in risk estimates clearly demonstrates that previous and current risk values for enteroviruses and Salmonella spp. are an underestimate of the total infective risk of pathogens contained in biosolids. Moreover, the consideration of pathogens (such as norovirus) in risk analysis that were not considered during the original analysis for Part 503 rule demonstrates that previous standards based on Salmonella spp. and enterovirus will not achieve the level of protection intended in these regulations.
Lawsuits and court cases
October 25, 2012 - 2 families won a $225,000 tort lawsuit against a sludge company that contaminated their properties.
An epic battle between the home rule of local government and states rights/commerce rights has been waged between the small town of Kern County, CA and Los Angeles, CA. Kern county passed an ordinance "Keep Kern Clean" ballot initiative which banned sludge from being applied in Kern County. Los Angeles sued and the case has yet to be decided.
On February 26, 2013 in Pennsylvania, the case Gilbert v. Synagro, a judge barred a nuisance, negligence and trespass lawsuit under PA's Right to Farm Act.
November 30, 2009, James Rosendall of Grand Rapids, MI was sentenced by United States District Judge Avern Cohn to 11 months in prison followed by three years of supervised release for conspiring to commit bribery Racketeer Influenced and Corrupt Organizations Act. Rosendall was the former president of Synagro of Michigan, a subsidiary of Synagro Technologies. His duties included obtaining the approval of the City of Detroit to process and dispose of the Cityâ€™s wastewater. United States Attorney Berg said: â€œIf a businessman seeking a contract with the City knowingly allows third-parties to bribe public officials to get that contract, this is a crime that deserves prison, which is what Mr. Rosendall got. In this case, Mr. Rosendallâ€™s significant cooperation and assistance in the investigation and prosecution of others resulted in a lower sentence than he would ordinarily would have received for complicity in such a bribery scheme.â€
November 9, 2012 - Synagro accused of illegal dumping that allegedly "risks of chemical exposure and explosions at the plant near Philadelphia International Airport." 
Local government ordinances and complaints
January 27, 2011 In Synagro's home state of Texas, Travis County Commissioners declared that Synagro's Solid Waste disposal activities would be inappropriate and prohibited land use according to the towns already established ordinances.
Background and history
Biosolids, the product generated from tertiary treatment of waste activated sludge, have been used in the UK, Europe and China agriculturally for more than 80 years, though there is increasing pressure to stop the practice of land application due to farm land contamination and public outrage. In the 1990s there was pressure in some European countries to ban the use of sewage sludge as a fertilizer. Switzerland, Sweden, Austria, and others introduced a ban. Since the 1960s there has been cooperative activity with industry to reduce the inputs of persistent substances from factories. This has been very successful and, for example, the content of cadmium in sewage sludge in major European cities is now only 1% of what it was in 1970.
European legislation on dangerous substances has eliminated the production and marketing of some substances that have been of historic concern such as persistent organic micropollutants. The European Commission has said repeatedly that the "Directive on the protection of the environment, and in particular of the soil, when sewage sludge is used in agriculture" (86/278/EEC) has been very successful in that there have been no cases of adverse effect where it has been applied. The EC encourages the use of sewage sludge in agriculture because it conserves organic matter and completes nutrient cycles. Recycling of phosphate is regarded as especially important because the phosphate industry predicts that at the current rate of extraction the economic reserves will be exhausted in 100 or at most 250 years.Template:Sims and Sharpley 2005 Phosphate can be recovered with minimal capital expenditure as technology currently exists, but municipalities have little political will to attempt nutrient extraction, instead opting for a "take all the other stuff" mentality.
Of general interest on this topic is the Swanson et al. (2004) brief history of sewage management in New York City [Swanson, R.L., M.L. Bortman, T.P. Oâ€™Connor, and H M. Stanford. 2004. Science, policy and the management of sewage materials; The New York City experience. Mar. Poll. Bull. 49: 679-687]. Since 1884 when sewage was first treated the amount of sludge has increased along with population and treatment technology. At first the sludge was discharged directly along the banks of rivers surrounding the city, then later piped further into the rivers, and then further still out into the harbor. In 1924, to relieve a dismal condition in New York Harbor which actually putrefied in places as a result of decay of sewage, New York City began dumping sludge at sea at a location in the New York Bight called the 12-Mile Site. This was deemed a successful public health measure and not until the late 1960s was there any examination of its consequences to marine life or to humans. There was accumulation of sludge particles on the seafloor and consequent changes in the numbers and types of benthic organisms. In 1970 a large area around the site was closed to shellfishing. From then until to 1986, the practice of dumping at the 12-Mile Site came under increasing pressure stemming from a series of untoward environmental crises in the New York Bight that were attributed partly to sludge dumping. In 1986, sludge dumping was moved still further seaward to a site over the deep ocean called the 106-Mile Site. Then, again in response to political pressure arising from events unrelated to ocean dumping, the practice ended entirely in 1992. Since 1992, New York City sludge has been applied to land (outside of New York state). That practice, now employed by two/thirds of the sewage treatment plants in the US, has been under continued scrutiny. The wider question is whether or not changes on the sea floor caused by the portion of sludge that settles are severe enough to justify the added operational cost and human health concerns of applying sludge to land. The cost versus benefit question is moot in the U.S. because ocean dumping of sludge is banned, but international treaty (London Dumping Convention) allows the practice so, on a global basis, as more and more sewage is treated, every sludge management option deserves practical consideration. Recent oceanic studies indicate that bacteria from human gut is destroying coral in the Caribbean.
The term biosolids was formally created in 1991 by the Name Change Task Force of the Water Environment Federation (WEF), formerly known as the "Federation of Sewage Works Associations" to differentiate raw, untreated sewage sludge from treated and tested sewage sludge that can legally be utilized as soil amendment and fertilizer. The Federation newsletter published a request for alternative names. Members sent in over 250 suggestions, including "all growth," "purenutri," "biolife," "bioslurp," "black gold," "geoslime," "sca-doo," "the end product," "humanure," "hu-doo," "organic residuals," "bioresidue," "urban biomass," "powergro," "organite," "recyclite," "nutri-cake" and "ROSE," short for "recycling of solids environmentally." In June 1991, the Name Change Task Force finally settled on "biosolids," which it defined as the "nutrient-rich, organic byproduct of the nation's wastewater treatment process."
The legal term for biosolids by law is sludge. Treatment processes only remove some cancer causing agents; others remain. As detailed in the 1995 Plain English Guide to the Part 503 Risk Assessment, EPA's most comprehensive risk assessment was completed for biosolids.
Sewage treatment plants receive all types of hazardous waste from hospitals, nursing homes, industry and households. Every household in the United States is authorized to discharge up to 220 pounds of hazardous waste per month to the sewage treatment plant  legally without reporting it. This is the equivalent to a household disposing 2 gallons of mercury down the drain, per month. At the waste water treatment plant, most of this metal would be separated from the water and concentrated into sludge. Mercury is well documented to have profound detrimental effect to human health as MSDS sheets show. Due to the lax regulations, hazardous waste, once passed through a sewage treatment plant, is determined as non-hazardous sewage sludge.
In 2013 in South Carolina PCBs were discovered in very high levels in wastewater sludge. The problem was not discovered until thousands of acres of farm land in South Carolina were contaminated by this hazardous material. An ongoing criminal investigation is underway to determine the perpetrator of this crime. While investigation was underway, SCDHEC issued emergency regulatory order banning all PCB laden sewage sludge from being land applied on farm fields or deposited into landfills in South Carolina.
Also in 2013, after DHEC request, the City of Charlotte decided to stop land applying sewage sludge in South Carolina while authorities investigated the source of PCB contamination. In February 2014, the City of Charlotte admits PCB's have entered their sewage treatment centers as well.
Sewage sludge is produced from the treatment of wastewater and consists of two basic forms â€” raw primary sludge (basically fecal material) and secondary sludge (a living â€˜cultureâ€™ of organisms that help remove contaminants from wastewater before it is returned to rivers or the sea). The sludge is transformed into biosolids using a number of complex treatments such as digestion, thickening, dewatering, drying, and lime/alkaline stabilization. Some treatment processes, such as composting and alkaline stabilization, that involve significant amendments may affect contaminant strength and concentration: depending on the process and the contaminant in question, treatment may decrease or in some cases increase the bioavailability and/or solubility of contaminants. In general, the more effectively a wastewater stream is treated, the greater the resulting concentration of contaminants into the product sludge. See also List of waste water treatment technologies.
Bacteria in Class A sludge products such as "Milorganite" can actually "rebloom" under certain environmental conditions.
Sewage treatment systems can have an "upset", meaning the bacteria that break the wastes down either all died or are unbalanced. Typically in these types of events the sludge will have a profuse odor, due to lack of active bacterial processes. Solvents, gasoline, paint thinner, high strength bleach, or other organic solvents can all cause significant upset to a sewage treatment plant. Upset is typically noticed very easily as the treatment plant will have a pungent and detectable odor near the facility for potentially weeks at a time.
Biosolids, also referred to as treated human sewage, is a term used by the waste water industry to denote the byproduct of domestic and commercial sewage and wastewater treatment. These residuals are further treated to reduce but not eliminate pathogens and vector attraction by any of a number of approved methods and then trucked and land applied to a farm field. Low levels of constituents such as PCBs, dioxin, and brominated flame retardants, may remain in treated sludge.
Recent conclusion of thorough review of literature and 20-year field study of air, land, and water in Arizona concluded that biosolids use is sustainable and improves the soil and crops. Other studies conclude that plants uptake large quantities of heavy metals and toxic pollutants that are retained by produce, which is then consumed by humans.
One of the main concerns in the treated sludge is the concentrated metals content; certain metals are regulated while others are not. Leaching methods can be used to reduce the metal content and meet the regulatory limit. The U.S. divides biosolids into two grades: Class B sewage sludge, and Class A treated sewage sludge. Class A sludge has been treated to reduce bacteria prior to application to land; Class B sludge has not.
Depending on their level of treatment and resultant pollutant content, biosolids can be used in regulated applications for non-food agriculture, food agriculture, or distribution for unlimited use. Treated biosolids can be produced in cake, granular, pellet or liquid form and are spread over land before being incorporated into the soil or injected directly into the soil by specialist contractors. It used to be common practice to dump sewage sludge into the ocean, however, this practice has stopped in many nations due to environmental concerns as well to domestic and international laws and treaties. In particular, after the 1991 Congressional ban on ocean dumping, the U.S. Environmental Protection Agency (EPA) instituted a policy of digested sludge reuse on agricultural land. The EPA promoted this policy by presenting it as recycling and rechristening sewage sludge as "biosolids", as they are solids produced by biological activities.
A 2004 survey of 48 individuals near affected sites found that most reported irritation symptoms, about half reported an infection within a month of the application, and about a fourth were affected by Staphylococcus aureus, including two deaths. The number of reported S. aureus infections was 25 times as high as in hospitalized patients, a high-risk group. The authors point out that regulations call for protective gear when handling Class B biosolids and that similar protections could be considered for residents in nearby areas given the wind conditions.
Khuder, Milz, Bisesi, Vincent, McNulty, and Czajkowski (as cited by Harrison and McBride of the Cornell Waste Management Institute in Case for Caution Revisited: Health and Environmental Impacts of Application of Sewage Sludges to Agricultural Land) conducted a health survey of persons living in close proximity to Class B sludged land. A sample of 437 people exposed to Class B sludge (living within 1-mile (1.6 km) of sludged land) - and using a control group of 176 people not exposed to sludge (not living within 1-mile (1.6 km) of sludged land) reported the following:
"Results revealed that some reported health-related symptoms were statistically significantly elevated among the exposed residents, including excessive secretion of tears, abdominal bloating, jaundice, skin ulcer, dehydration, weight loss, and general weakness. The frequency of reported occurrence of bronchitis, upper respiratory infection, and giardiasis were also statistically significantly elevated. The findings suggest an increased risk for certain respiratory, gastrointestinal, and other diseases among residents living near farm fields on which the use of biosolids was permitted."
â€”Khuder, et al., Health Survey of Residents Living near Farm Fields Permitted to Receive Biosolids
Harrison and Oakes suggest that, in particular, "until investigations are carried out that answer these questions (...about the safety of Class B sludge...), land application of Class B sludges should be viewed as a practice that subjects neighbors and workers to substantial risk of disease." They further suggest that even Class A treated sludge may have chemical contaminants (including heavy metals, such as lead) or endotoxins present, and a precautionary approach may be justified on this basis, though the vast majority of incidents reported by Lewis, et al. have been correlated with exposure to Class B untreated sludge and not Class A treated sludge.
A 2005 report by the state of North Carolina concluded that "that a surveillance program of humans living near application sites should be developed to determine if there are adverse health effects in humans and animals as a result of biosolids application."
In 2009 the EPA released the Targeted National Sewage Sludge Study, which reports on the level of metals, chemicals, hormones, and other materials present in a statistical sample of sewage sludges. Some highlights include:
- Silver is present to the degree of 20 mg/kg of sludge, on average, a near economically recoverable level, while some sludges of exceptionally high quality have up to 200 milligrams of silver per kilogram of sludge; one outlier demonstrated a silver lode of 800â€“900 mg per kg of sludge.
- Barium is present at the rate of 500 mg/kg, while manganese is present at the rate of 1 g/kg sludge.
- High levels of sterols and other hormones have been detected, with averages in the range of up to 1,000,000 Âµg/kg sludge.
- Lead, arsenic, chromium, and cadmium are estimated by the EPA to be present in detectable quantities in 100% of national sewage sludges in the US, while thallium is only estimated to be present in 94.1% of sludges.
Recent studies (2010) have indicated that pharmaceuticals and personal care products, which often adsorb to sludge during wastewater treatment, can persist in agricultural soils following biosolid application. Some of these chemicals, including potential endocrine disruptor Triclosan, can also travel through the soil column and leach into agricultural tile drainage at detectable levels. Other studies, however, have shown that these chemicals remain adsorbed to surface soil particles, making them more susceptible to surface erosion than infiltration. These studies are also mixed in their findings regarding the persistence of chemicals such as triclosan, triclocarban, and other pharmaceuticals. The impact of this persistence in soils is unknown, but the link to human and land animal health is likely tied to the capacity for plants to absorb and accumulate these chemicals in their consumed tissues. Studies of this kind are in early stages, but evidence of root uptake and translocation to leaves did occur for both triclosan and triclocarban in soybeans. This effect was not present in corn when tested in a different study.
A PhD thesis studying the addition of sludge to neutralize soil acidity concluded that the practice was not recommended if large amounts are used because the sludge produces acids when it oxidizes.
Alternatives to land-based management of biosolids that avoid the above-described potential impacts to the environment and public health are any number of thermally-based processes such as incineration, gasification or the Gate 5 Energy System.
Food production classification
However, for Good Agricultural Practices, sludge can be used and is encouraged. Even if a farmer chooses not to use sludge on their GAP certified farm, a neighbor may top dress sludge on a plat adjacent and potentially contaminate the farmers crop, sickening and/or poisoning the general public.
Classes of sewage sludge
Class A sludge is typically dried and pasteurized, and is also known as "exceptional" quality.
Class B includes all sludge not classified as Class A. Class B sludge is typically "undigested" and is volatile. Residents living near Class B sludge processing sites may experience asthma or pulmonary distress due to bioaerosols released from sludge fields.
According to the EPA, biosolids that meet treatment and pollutant content criteria of Part 503.13 "can be safely recycled and applied as fertilizer to sustainably improve and maintain productive soils and stimulate plant growth." However, they can not be disposed of in a sludge only landfill under Part 503.23 because of high chromium levels and boundary restrictions. After the 1991 Congressional ban on ocean dumping, the US EPA promulgated regulations - 40 CFR Part 503 - that continued to allow the use of biosolids on land as fertilizers and soil amendments which had been previously allowed under Part 257. The EPA promoted biosolids recycling throughout the 1990s. The EPA's Part 503 regulations were developed with input from university, EPA, and USDA researchers from around the country and involved an extensive review of the scientific literature and the largest risk assessment the agency had conducted to that time. However, there was no risk assess for pathogens or chemicals and heavy metals were not considered to be cancer causing agents. The Part 503 regulations became effective in 1993.
United States municipal wastewater treatment plants in 1997 produced about 7.7 million dry tons of biosolids, and about 6.8 million dry tons in 1998 according to sources relying on EPA estimates. As of 2002, about 60% of all biosolids were applied to land as a soil amendment and fertilizer for growing crops. Biosolids that meet the Class B pathogen treatment and pollutant criteria, in accordance with the EPA "Standards for the use or disposal of sewage sludge" (40 CFR Part 503), can be land applied with formal site restrictions and strict record keeping. Biosolids that meet Class A pathogen reduction requirements or equivalent treatment by a "Process to Further Reduce Pathogens" (PFRP) have the least restrictions on use. PFRPs include pasteurization, heat drying, thermophilic composting (aerobic digestion, most common method), and beta or gamma ray irradiation. Processes to reduce pathogens have no effect on heavy metals and may or may not have effects on the levels of other trace pollutants in biosolids. Treatment processes that involve significant amendments such as composting and alkaline stabilization may dilute total trace metals concentrations, but, depending on the process and the element in question, may decrease or in some cases increase the bioavailability and/or solubility of trace elements. "Composting is not a sterilization process and a properly composted product maintains an active population of beneficial microorganisms that compete against the pathogenic members. Under some conditions, explosive regrowth of pathogenic microorganisms is possible."
Often thought to consist of only "human waste", treated sewage sludge or "biosolids" contain any contaminants from sewage that are not broken down in the treatment process, or which do not remain with the water effluent leaving the treatment plant. The most commonly detected trace contaminants of concern are heavy metals (arsenic, cadmium, copper, etc., some of which are also critical plant micronutrients), and toxic chemicals (e.g. plasticizers, PDBEs, and others generated by human activities, including personal care products and medicines). Synthetic fibers from fabrics persist in biosolids as well as in biosolids-treated soils and may thus serve as an indicator of past biosolids application. Pathogens are not a significant health issue if biosolids are properly treated and site-specific management practices are followed; there is generally a greater concern for products that have been fertilized with un-treated animal wastes and which may be eaten raw.
The National Research Council published "Biosolids Applied to Land: Advancing Standards and Practices" in July 2002. The NRC concluded that while there is no documented scientific evidence that sewage sludge regulations have failed to protect public health, there is persistent uncertainty on possible adverse health effects. The NRC noted that further research is needed and made about 60 recommendations for addressing public health concerns, scientific uncertainties, and data gaps in the science underlying the sewage sludge standards. EPA responded with a commitment to conduct research addressing the NRC recommendations.
The EPA Office of the Inspector General (OIG) completed two assessments in 2000 and 2002 of the EPA sewage sludge program. The follow-up report in 2002 documented that "the EPA cannot assure the public that current land application practices are protective of human health and the environment." The report also documented that there had been an almost 100% reduction in EPA enforcement resources since the earlier assessment. This is probably the greatest issue with the practice: under both the federal program operated by the EPA and those of the several states, there is limited inspection and oversight by agencies charged with regulating these practices. To some degree, this lack of oversight is a function of the perceived (by the regulatory agencies) benign nature of the practice. However, a greater underlying issue is funding. Few states and the US EPA have the discretionary funds necessary to establish and implement a full enforcement program for biosolids. To do so would require substantial spending that most legislatures are unwilling to support. Some states and companies involved in biosolids management have willingly agreed to use a "fee" per unit of biosolids managed to help fund such programs, and generally, where such programs are in place, biosolids land application proceeds without incident, however these fees are seldom sufficient to fully fund a rigorous inspection program.
A cautionary approach to land application of biosolids has been advocated by some for regions where soils have lower capacities for toxics absorption or due to the presence of unknowns in sewage biosolids. In 2007 the Northeast Regional Multi-State Research Committee (NEC 1001) issued conservative guidelines tailored to the soils and conditions typical of the northeastern US.
Most people are unaware what happens to the toilet waste once they flush. For folks in rural areas, such as Kern County, CA, they are very familiar with Los Angeles toilet byproducts as are innocent land owners across the country.
In 1994, Michael Moore on his program TV Nation, produced an editorial piece on Sierra Blanca, Texas: how NY Sewage was being hauled to Texas and dumped near the impoverished town. Merco, the company profiting from the practice, retaliated with a libel lawsuit against Kaufman, TV Nation and its parent company, TriStar Television but the case was dismissed on appeal.
Impact on neighbours
Farmers can save money from not having to purchase fertilizer. Sewage sludge typically is provided free of charge. Municipal sewage districts save large amounts of money by not having to pay expensive landfill costs, typically between $75â€“$90/ton. Sludge spreaders, such as WeCareOrganics and Synagro, typically gross between $10â€“20/ton from municipalities to remove sludge and deliver and spread on farm fields. In Charlotte County, Florida, a recent proposal has the potential to earn Synagro over $1.2 million in annual revenue.
Residents living nearby sludge spreading sites may be unable to sell their homes due to poor odours and health concerns, such as an increased risk of developing asthma and the potential presence of Escherichia coli in drinking water.
In 2001 in Baltimore, Maryland, scientists using federal grants spread fertilizer made from human and industrial wastes on yards in poor, black neighborhoods to test whether it might protect children from lead poisoning in the soil. Residents sued and the Maryland court system likened the study to experiments performed in the Nazi concentration camps of World War II: "These programs were somewhat alike in the vulnerability of the subjects: uneducated African-American men, debilitated patients in a charity hospital, prisoners of war, inmates of concentration camps and others falling within the custody and control of the agencies conducting or approving the experiments," the court said.
In 2011, a cantaloupe-processing facility became contaminated with listeria. Upon closer inspection, it was discovered that a Class B sludge disposal site was located close to the plant. The CDC is currently[dated info] investigating to see if the sludge is connected to the listeria outbreak that could have killed over 30 people and sickened 146.
Modern cremation techniques such as resomation are an additional source of controversy, as the liquified human remains are mixed in sewage sludge and deposited on farm fields to grow human food. There may be religious objections to this process.
Dr. David Lewis worked for the EPA for 31 years. In a peer-reviewed article in Environmental Science & Technology he showed that pathogens could easily remain undetected in untreated sewage sludge. Since the government is pushing the use of this sludge for agricultural fertilizer, Lewis was harassed and finally fired in May 2003. At a hearing on the role of science in shaping public policy he charged the EPA with "corrupt[ing] the scientific peer review process in order to support certain political agendas and further the agency's self-interest."
Alternative pathways for sludge reuse
Feridun of the United Sludge Free Alliance suggests that sludge can be recycled in a variety of ways that are both environmentally beneficial and sustainable, and which do not involve application of biologically active materials to croplands that humans live close to. These include using anaerobic digestion to produce biogas, pyrolysis of the sludge to create syngas and potentially biochar, combustion of biofuel produced from drying biosolids or incineration in a waste-to-energy facility for direct production of electricity and steam for district heating or industrial uses. Synergies from these processes include (a) nomethane release (an extremely potent greenhouse gas) if the biofuel is combusted, or (b) in the case of anaerobically digested biosolids a far lower, controlled level of methane released to the atmosphere from the pyrolyzed/digested/combusted sludge rather than the uncontrolled release of methane from untreated or land applied sludge. If methane is captured rather than allowed to outgas, it can be used for fuel, closing the carbon cycle. Thermal processes can eliminate and anaerobic processes can greatly reduce the volume of the sludge, as well as achieve remediation of all or some of the biological concerns. Direct waste-to-energy incineration and complete combustion systems (such as the Gate 5 Energy System) will require multi-step cleaning of the exhaust gas, to ensure no hazardous substances are released. In addition, the ash produced by incineration or incomplete combustion processes (such as fluidized-bed dryers) may be difficult to use without subsequent treatment due to high heavy metal content; solutions to this include leaching of the ashes to remove heavy metals or in the case of ash produced in a complete-combustion process, or with biochar produced from a pyrolytic process, the heavy metals may be fixed in place and the ash material readily usable as a LEEDs preferred additive to concreate or asphalt. Examples of other ways to use dried sewage sludge as an energy resource include (1) the Gate 5 Energy System, an innovative process to power a steam turbine using heat from burning milled and dried biosolids, or (2) combining dried biosolids with coal in coal-fired power stations. In both cases this allows for production of electricity with less carbon-dioxide emissions than conventional coal-fired power stations.
|Look up sludge in Wiktionary, the free dictionary.|
- Aerobic granular sludge technology
- Ecological sanitation
- Oil sludge
- Sewage treatment
- Suspended solids
- Wastewater treatment facility
- Drinking water treatment sludge production and dewaterability
- http://www.cefns.nau.edu/Projects/WDP/resources/History/History.htm. Missing or empty
- "Human sewage ocean dumping ban". http://www.nytimes.com/1992/06/29/nyregion/ocean-dumping-ending-but-not-problems-new-york-can-t-ship-bury-burn-its-sludge.html?pagewanted=all&src=pm.
- http://nepis.epa.gov/Exe/ZyNET.exe/9100FMSN.TXT?ZyActionD=ZyDocument&Client=EPA&Index=1976+Thru+1980&Docs=&Query=&Time=&EndTime=&SearchMethod=1&TocRestrict=n&Toc=&TocEntry=&QField=&QFieldYear=&QFieldMonth=&QFieldDay=&IntQFieldOp=0&ExtQFieldOp=0&XmlQuery=&File=D%3A%5Czyfiles%5CIndex%20Data%5C76thru80%5CTxt%5C00000015%5C9100FMSN.txt&User=ANONYMOUS&Password=anonymous&SortMethod=h%7C-&MaximumDocuments=1&FuzzyDegree=0&ImageQuality=r75g8/r75g8/x150y150g16/i425&Display=p%7Cf&DefSeekPage=x&SearchBack=ZyActionL&Back=ZyActionS&BackDesc=Results%20page&MaximumPages=1&ZyEntry=1&SeekPage=x&ZyPURL. Missing or empty
- http://aem.asm.org/content/78/18/6643.full. Missing or empty
- http://www.synagro.com/solutions/reusing/land-application/. Missing or empty
- "Biosolids = PR redefine human waste".
- "Interview with author of 'Toxic Sludge is Good For You'".
- "Sludge rebranded as compost in latest PR campaign".
- "EPA Classifies sludge as a Pollutant".
- "EPA Study of emerging pollutants of concern".
- "2011 EPA NRC Human Health Risk Study".
- "FRIFOOD SAFETY REVIEW: Non-O157:H7 Shiga Toxin-producing E. coli from Meat and Non-Meat Sources".
- "MICROBIOLOGICAL SAFETY OF ORGANIC FERTILIZERS USED FOR PRODUCE PRODUCTION".
- Eamens, G. J.; Waldron, A. M.; Nicholls, P. J. (2006). "Survival of pathogenic and indicator bacteria in biosolids applied to agricultural land". Australian Journal of Soil Research 44 (7): 647â€“59. doi:10.1071/SR06015.
- Higgins MJ, Chen YC, Murthy SN, Hendrickson D (24â€“27 June 2007). LeBlanc RJ, Laughton PJ, Tyagi R, ed. "Latest Developments on the Emerging Issue of E. coli and Fecal Coliform Reactivation and Regrowth after Dewatering". Proceedings on Moving Forward Wastewater Biosolids Sustainability: Technical, Managerial, and Public Synergy. New Brunswick, GMSC. pp. 209â€“15.
- http://www.sludgenews.org/resources/documents/Viau_Infectious_Risks.pdf. Missing or empty
- "Sludge Tort Lawsuit won in Oklahoma".
- "Kern County vs LA".
- "Gilbert_v_synagro lawsuit".
- "Former Synagro Executive guilty of bribing City officials".
- "Synagro Bribe Caught on FBI Tape".
- "Synagro Accused of illegal dumping".
- "Travis County - Sludge violates local ordinances".
- "Over 10% China farm land toxic".
- "USA Outrage over Sewage Sludge".
- "Europe Sludge Outrage".
- "San Francisco Outrage".
- "Recovering phosphorus".
- "Caribbean Coral Catch Pox from Sewage".
- Sludge News | Timeline
- "RCRA". Deadlydeceit.com. Retrieved 2013-10-05.
- "A Guide to the Biosolids Risk Assessments for the EPA Part 503 Rule | Biosolids | US EPA". Water.epa.gov. Retrieved 2013-10-05.
- "EPA limits to household hazardous waste disposal".
- "Weight of 1 gallon of mercury".[unreliable source?]
- "MSDS for mercury".
- "City of Charlotte stops land applying sludge in SC".
- "Chalotte finds PCB's in its waste treatment stream". Charlotte Observer.
- "Congressional Research Service - how to defend nations infrastructure".
- Richards, Brian K.; Peverly, John H.; Steenhuis, Tammo S.; Liebowitz, Barry N. (1997). "Effect of Processing Mode on Trace Elements in Dewatered Sludge Products". Journal of Environmental Quality 26 (3): 782â€“8. doi:10.2134/jeq1997.00472425002600030027x.
- Jolis, D (2006). "Regrowth of fecal coliforms in class a biosolids". Water environment research 78 (4): 442â€“5. doi:10.2175/106143005X90074. PMID 16749313.
- "Upset belly of a wastewater treatment plant".
- "Chemicals of concern in a waste water treatment plant".
- EBMUD's Biosolids FAQ
- Understanding Biosolids - Chapter 7 Synthetic Organic Chemicals in Biosolids, C. Henry, UWB, 2005
- Household Chemicals and Drugs Found in Biosolids from Wastewater Treatment Plants, United States Geological Survey
- Intawongse, Marisa; Dean, John R. (2006). "Uptake of heavy metals by vegetable plants grown on contaminated soil and their bioavailability in the human gastrointestinal tract". Food Additives and Contaminants 23 (1): 36â€“48. doi:10.1080/02652030500387554. PMID 16393813.
- Zhu, Y-G.; Smolders, E (2000). "Plant uptake of radiocaesium: A review of mechanisms, regulation and application". Journal of Experimental Botany 51 (351): 1635â€“45. doi:10.1093/jexbot/51.351.1635. PMID 11053452.
- Travis, Curtis C.; Hattemer-Frey, Holly A. (1988). "Uptake of organics by aerial plant parts: A call for research". Chemosphere 17 (2): 277â€“83. doi:10.1016/0045-6535(88)90220-2.
- McBride, M. B.; Richards, B. K.; Steenhuis, T.; Spiers, G. (2000). "Molybdenum Uptake by Forage Crops Grown on Sewage Sludge-Amended Soils in the Field and Greenhouse". Journal of Environmental Quality 29 (3): 848â€“54. doi:10.2134/jeq2000.00472425002900030021x.
- Kim, Bojeong; McBride, Murray B.; Richards, Brian K.; Steenhuis, Tammo S. (2007). "The long-term effect of sludge application on Cu, Zn, and Mo behavior in soils and accumulation in soybean seeds". Plant and Soil 299: 227â€“36. doi:10.1007/s11104-007-9377-3.
- McBride, M. B. (2005). "Molybdenum and Copper Uptake by Forage Grasses and Legumes Grown on a Metalâ€Contaminated Sludge Site". Communications in Soil Science and Plant Analysis 36 (17â€“18): 2489â€“501. doi:10.1080/00103620500255840.
- McBride, M.B. (2003). "Toxic metals in sewage sludge-amended soils: Has promotion of beneficial use discounted the risks?". Advances in Environmental Research 8: 5â€“19. doi:10.1016/S1093-0191(02)00141-7.
- "Removal of Heavy Metals from Sewage Sludge Used as Soil Fertilizer". Soil and Sediment Contamination 14 (2): 143â€“54. 2005. doi:10.1080/15320380590911797.
- Harrison, Ellen Z.; Oakes, Summer Rayne (2003). "Investigation of alleged health incidents associated with land application of sewage sludges". New Solutions 12 (4): 387â€“408. doi:10.2190/0FJ0-T6HJ-08EM-HWW8. PMID 17208785.
- http://www.nefcobiosolids.com/[full citation needed]
- Lewis, David L; Gattie, David K; Novak, Marc E; Sanchez, Susan; Pumphrey, Charles (2002). "Interactions of pathogens and irritant chemicals in land-applied sewage sludges (biosolids)". BMC Public Health 2: 11. doi:10.1186/1471-2458-2-11. PMC 117218. PMID 12097151.
- Khuder, Sadik; Milz, Sheryl A.; Bisesi, Michael; Vincent, Robert; McNulty, Wendy; Czajkowski, Kevin (2007). "Health Survey of Residents Living Near Farm Fields Permitted to Receive Biosolids". Archives of Environmental & Occupational Health 62 (1): 5â€“11. doi:10.3200/AEOH.62.1.5-11. PMID 18171641.
- "Human Health Risk".
- [[Office of Water|Office of Water, United States Environmental Protection Agency]] (2009-01-15). "Targeted National Sewage Sludge Survey Statistical Analysis Report". Targeted National Sewage Sludge Survey. Federal Government of the United States of America. Retrieved 2009-08-06.
- Edwards, M., et al. (2009) "Pharmaceutical and personal care products in tile drainage following surface spreading and injection of dewatered municipal biosolids to an agricultural field." Science of the Total Environment 407: 4220-30.
- Xia, Kang; Hundal, Lakhwinder S.; Kumar, Kuldip; Armbrust, Kevin; Cox, Albert E.; Granato, Thomas C. (2010). "Triclocarban, triclosan, polybrominated diphenyl ethers, and 4-nonylphenol in biosolids and in soil receiving 33-year biosolids application". Environmental Toxicology and Chemistry 29 (3): 597â€“605. doi:10.1002/etc.66. PMID 20821484.
- Cha, Jongmun; Cupples, Alison M. (2009). "Detection of the antimicrobials triclocarban and triclosan in agricultural soils following land application of municipal biosolids". Water Research 43 (9): 2522â€“30. doi:10.1016/j.watres.2009.03.004. PMID 19327812.
- Cha, Jongmun; Cupples, Alison M. (2010). "Triclocarban and triclosan biodegradation at field concentrations and the resulting leaching potentials in three agricultural soils". Chemosphere 81 (4): 494â€“9. doi:10.1016/j.chemosphere.2010.07.040. PMID 20705327.
- Wu, Chenxi; Spongberg, Alison L.; Witter, Jason D.; Fang, Min; Czajkowski, Kevin P. (2010). "Uptake of Pharmaceutical and Personal Care Products by Soybean Plants from Soils Applied with Biosolids and Irrigated with Contaminated Water". Environmental Science & Technology 44 (16): 6157â€“61. doi:10.1021/es1011115. PMID 20704212.
- Basque Research. (2009). Adding high doses of sludge to neutralize soil acidity not advisable. The University of the Basque Country.
- "Organic label designations".
- "GAP and municipal waste".
- "Listeria outbreak possible link to sewage sludge".
- Paez-Rubio, T.; Viau, E.; Romero-Hernandez, S.; Peccia, J. (2005). "Source Bioaerosol Concentration and rRNA Gene-Based Identification of Microorganisms Aerosolized at a Flood Irrigation Wastewater Reuse Site". Applied and Environmental Microbiology 71 (2): 804â€“10. doi:10.1128/AEM.71.2.804-810.2005. PMC 546674. PMID 15691934.
- Douwes, J.; Thorne, P; Pearce, N; Heederik, D (2003). "Bioaerosol Health Effects and Exposure Assessment: Progress and Prospects". Annals of Occupational Hygiene 47 (3): 187â€“200. doi:10.1093/annhyg/meg032. PMID 12639832.
- "medical waste".
- http://spectrum.ieee.org/tech-talk/energy/nuclear/radioactive-sludge-collects-in-japans-sewage-treatment-plants[full citation needed]
- http://deadlydeceit.com/503-Riskassessment.html[full citation needed]
- Sec. 503.16 Frequency of monitoring
- EPA specification for PFR Processes
- Biosolids Technology Fact Sheet USEPA
- Sec. 503.13 EPA Pollutant limits
- Zubris, Kimberly Ann V.; Richards, Brian K. (2005). "Synthetic fibers as an indicator of land application of sludge". Environmental Pollution 138 (2): 201â€“11. doi:10.1016/j.envpol.2005.04.013. PMID 15967553.
- Investigation of anecdotal health reports
- NRC report on biosolids standards
- EPA response to NRC report
- Harrison, Ellen Z.; McBride, Murray B.; Bouldin, David R. (1999). "Land application of sewage sludges: An appraisal of the US regulations". International Journal of Environment and Pollution 11: 1â€“36. doi:10.1504/IJEP.1999.002247.
- Harrison, E.Z. and M.B. McBride. 2008. The Case for Caution Revisited
- Barker, Allen; Harrison, Ellen Z.; Hay, Anthony; Krogmann, Uta; McBride, Murray; McDowell, William; Richards, Brian; Steenhuis, Tammo; Stehouwer, Richard (April 2007). Harrison, Ellen Z.; Krogmann, Uta, eds. Guidelines for Application of Sewage Biosolids to Agricultural Lands in the Northeastern U.S. Rutgers NJAES Cooperative Extension. hdl:1813/7934.
- "Kern County Lawsuit".[unreliable source?]
- "merco lawsuit".
- http://www.txpeer.org/toxictour/merco.html[full citation needed]
- "expensive landfill option".
- "How Synagro Makes Money".
- "sludge smells".
- "kern county, LA's toilet".
- "asthma concerns".
- P D Millner; Marsh, PB; Snowden, RB; Parr, JF (1977-12-01). "Occurrence of Aspergillus fumigatus during composting of sewage sludge". Applied and Environmental Microbiology 34 (6): 765â€“72. PMC 242745. PMID 339835.
- "ecoli possibly from sludge".
- "Disavantaged Sewage Sludge Lawsuit". Fox News. 2008-04-14.[dead link]
- Kost, Amanda. "Exclusive: Biosolids Near farm field examined for Listeria Link".
- "CDC Cantaloupe Listeria Outbreak possibly due to biosolds".
- "Resomation waste goes to sewer system".
- "Religious objections to liquifying people and using remains to grow food".
- Lewis, David L.; Gattie, David K. (2002). "Peer Reviewed: Pathogen Risks from Applying Sewage Sludge to Land". Environmental Science & Technology 36 (13): 286A. doi:10.1021/es0223426. Lay summary â€“ ScienceDaily (July 30, 2002).
- "EPA and the University of Georgia using fabricated data to cover up cattle deaths".
- Feridun, Karen (2009-04-13). "Alternative Uses for Sludge". http://www.uSludgeFree.org. United Sludge Free Alliance. Retrieved 2009-07-07.[dead link]
- Cartmell, Elise; Gostelow, Peter; Riddell-Black, Drusilla; Simms, Nigel; Oakey, John; Morris, Joe; Jeffrey, Paul; Howsam, Peter; Pollard, Simon J. (2006). "Biosolidsâ€”A Fuel or a Waste? An Integrated Appraisal of Five Co-combustion Scenarios with Policy Analysis". Environmental Science & Technology 40 (3): 649â€“58. doi:10.1021/es052181g. PMID 16509299.
- John Stauber; Sheldon Rampton (1995). "Chapter 8: The Sludge Hits the Fan". Toxic Sludge is Good For You. Common Courage Press. ISBN 1-56751-060-4.
Government and NGO reports
- "Biosolids Applied to Land: Advancing Standards and Practices", National Research Council, July 2002
- Guidance For Controlling Potential Risks To Workers Exposed to Class B Biosolids, Center for Disease Control (CDC), July, 2002
- Why USDA Should Just Say No: Executive Summary, Environmental Working Group, April 1998
- Why USDA Should Just Say No: Policy Memo, Environmental Working Group, April 1998
- Human Health Risk Evaluation of Land Application of Sewage Sludge/Biosolids, North Carolina Health Department: Occupational and Environmental Epidemiology Branch, November 2005.
- Gattie, David K.; Lewis, David L. (2004). "A High-Level Disinfection Standard for Land-Applied Sewage Sludges (Biosolids)". Environmental Health Perspectives 112 (2): 126â€“31. doi:10.1289/ehp.6207. JSTOR 3435552. PMC 1241820. PMID 14754565.
- Snyder, C (2005). "The dirty work of promoting "recycling" of America's sewage sludge". International journal of occupational and environmental health 11 (4): 415â€“27. PMID 16350476.
- Harrison, Ellen Z.; McBride, Murray B.; Bouldin, David R. (1999). "Land application of sewage sludges: An appraisal of the US regulations". International Journal of Environment and Pollution 11: 1. doi:10.1504/IJEP.1999.002247.